A Space & astronomy forum. SpaceBanter.com

Go Back   Home » SpaceBanter.com forum » Space Science » Space Shuttle
Site Map Home Authors List Search Today's Posts Mark Forums Read Web Partners

Wing breached 3 times



 
 
Thread Tools Display Modes
  #1  
Old July 9th 03, 01:20 PM
Hallerb
external usenet poster
 
Posts: n/a
Default Wing breached 3 times

http://www.floridatoday.com/columbia...ory2A5346A.htm
  #2  
Old July 10th 03, 12:21 AM
Tim Kozusko
external usenet poster
 
Posts: n/a
Default Wing breached 3 times


Hallerb wrote in message
...
http://www.floridatoday.com/columbia...ory2A5346A.htm


I saw that this morning and to be honest, it made me a bit sick to my
stomach. I'm not ready to become a NASA-basher yet, but Jesus what were
they thinking.
end emotional response to an engineering problem


  #3  
Old July 10th 03, 03:04 AM
Hallerb
external usenet poster
 
Posts: n/a
Default Wing breached 3 times

I saw that this morning and to be honest, it made me a bit sick to my
stomach. I'm not ready to become a NASA-basher yet, but Jesus what were
they thinking.
end emotional response to an engineering problem


A Florida Today review of mission and runway inspection reports as well as
separate NASA problem reports, many of which the newspaper obtained under the
Freedom of Information Act, showed that damage to the leading edge of the
shuttles' wings is not uncommon or new.

The three previous breaches are significant.

The composite carbon panels encounter temperatures as high as 3,000 degrees
Fahrenheit during atmospheric re-entry. A penetration of hot gases,
consequently, can lead to the loss of a $2 billion shuttle and its astronaut
crew.

The problem dates back to the early days of the shuttle program.

On NASA's second shuttle flight in November 1981, hot gases blasted past
Columbia's wing panels near a spot where they join with heat-shield tiles on
the underside of the orbiter, according to a mission report.

The searing heat scorched and burned through a fiber barrier used to fill gaps
between heat-shield components. The gases streaked an aluminum spar inside one
of wing, the report says.

NASA subsequently modified the thermal barrier and saw less damage on the next
flight.

A similar problem, however, cropped up again on NASA's fifth shuttle flight in
November 1982 -- another Columbia mission.

A jet of hot gas melted a small hole in a tile-covered metal bar connected to a
wing panel. It damaged internal insulation but none of the metal components
inside the wing, a mission report says.

No damage was noted on the next flight.

A more recent incident came at the end of a May 2000 Atlantis mission to the
International Space Station. On that flight, hot gases penetrated a dislodged
seal between two panels on the shuttle's left wing.

A subsequent investigation showed the seal had been installed improperly during
a shuttle overhaul, creating a quarter-inch gap that served as a "substantial
flow path" for hot gases, a NASA document says.

Charred and scorched as a result: Internal components made of Inconel and
titanium – metals that have melting points between 2,500 and 3,000 degrees,
respectively.

The damage was repaired and NASA ordered changes in the way that seals between
wing panels are installed.

Less threatening but still significant damage has been more common.

Micrometeoroids and launch debris strikes dented or cracked wing panels on at
least nine missions between April 1991 and March 2001, NASA records show.

Wing panels also have been damaged by exposure to extreme temperatures and
pressures encountered during flight. And zinc primer leaching off the launch
tower has corroded them.

The lesser damage has ranged from small pits to larger cracks.

Investigators have raised concerns about whether the panels weaken with age
too. Only three of Columbia's panels were replaced during its 22 years of
flight.

Investigators, meanwhile, think even a relatively small crack in a wing panel
could doom a shuttle crew. The damage done to Columbia, however, likely was
more dramatic.

I


 




Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

vB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
Shuttle Foam Test Yields Hole in Wing - Associated Press Rusty B Space Shuttle 29 August 12th 03 03:30 AM
Columbia Investigators Fire Foam Insulation at Shuttle Wing, Blowing Open 2-Foot Hole; The crowd of about 100 gasped and cried, "Wow!" when the foam hit. Jay Space Shuttle 32 July 12th 03 02:41 AM
Gases Breached Wing of Shuttle Atlantis in 2000 Hallerb Space Shuttle 6 July 10th 03 06:08 PM
NASA: Gases Breached Wing of Shuttle Atlantis in 2000 Rusty Barton Space Shuttle 2 July 10th 03 01:27 AM
Dittemore said if shuttle crippled nothing could be done - LA Times erroneously reports Kent Betts Space Shuttle 0 July 5th 03 11:39 AM


All times are GMT +1. The time now is 11:14 PM.


Powered by vBulletin® Version 3.6.4
Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.
Copyright ©2004-2024 SpaceBanter.com.
The comments are property of their posters.